PROBLEM SYMPTOMS TABLE
HINT:
Use the table below to help determine the cause of problem symptoms. If multiple suspected areas are listed, the potential causes of the symptoms are listed in order of probability in the "Suspected Area" column of the table. Check each symptom by checking the suspected areas in the order they are listed. Replace parts as necessary.
Symptom |
Suspected Area |
See page |
---|---|---|
Hard steering |
Tires (Improperly inflated) |
|
Power steering fluid level (Low) |
|
|
Drive belt (Loose) (2TR-FE) |
|
|
Drive belt (Loose) (2GR-FKS) |
|
|
Front wheel alignment (Incorrect) |
|
|
Steering system joints (Worn) |
- |
|
Suspension arm ball joints (Worn) |
|
|
Steering column (Binding) |
- |
|
Vane pump (2TR-FE) |
|
|
Vane pump (2GR-FKS) |
|
|
Power steering link (2TR-FE) |
|
|
Power steering link (2GR-FKS) |
|
|
Poor return |
Tires (Improperly inflated) |
|
Front wheel alignment (Incorrect) |
|
|
Steering column (Binding) |
- |
|
Power steering link (2TR-FE) |
|
|
Power steering link (2GR-FKS) |
|
|
Excessive play |
Steering system joints (Worn) |
- |
Suspension arm ball joints (Worn) |
|
|
Intermediate shaft, Sliding yoke (Worn) |
- |
|
Front wheel bearing (Worn) |
|
|
Power steering link (2TR-FE) |
|
|
Power steering link (2GR-FKS) |
|
|
Abnormal noise |
Power steering fluid level (Low) |
|
Steering system joints (Worn) |
- |
|
Vane pump (2TR-FE) |
|
|
Vane pump (2GR-FKS) |
|
|
Power steering link (2TR-FE) |
|
|
Power steering link (2GR-FKS) |
|
Crankshaft Position Sensor
Components
COMPONENTS
ILLUSTRATION
Installation
INSTALLATION
PROCEDURE
1. INSTALL CRANKSHAFT POSITION SENSOR
(a) Apply a light coat of engine oil to the O-ring of the crankshaft position
sensor.
NOTICE:
When reusing the crankshaft position sensor, inspect the O-ring.
...
Removal
REMOVAL
PROCEDURE
1. PRECAUTION
NOTICE:
After turning the ignition switch off, waiting time may be required before disconnecting
the cable from the negative (-) battery terminal. Therefore, make sure to read the
disconnecting the cable from the negative (-) battery terminal notices before pr ...
Removal
REMOVAL
CAUTION / NOTICE / HINT
NOTICE:
If one of the camshaft timing gear bolts is already removed, do not remove any
other camshaft timing gear bolts.
PROCEDURE
1. REMOVE NO. 2 ENGINE UNDER COVER SUB-ASSEMBLY (w/ Off Road Package)
2. REMOVE NO. 1 ENGINE UNDER COVER SUB-ASSEMBLY
3. REMOVE ...